WILL NOT START
PROBLEM
r',/tLLNOT TURN OVER
ENGINE CLICKS BUT WON'T START
HARD TO START
ENGINE MISSES OR LACKS POWER
ENGINE OVERHEATS
NO LIGHTS
WON'T CHARGE
OPERATOR PRESENCE SYSTEM W! LL NoT
TROUBLESHOOTING"
CAUSE / REMEDY (SEE INDEX)
Fill Tank with Gasoline, Check Fuel Line and Carburetor
(clean if necessary), Replace Fuel Filter Use Fresh Fuel
Recharge or replace Battery
Check Wiring
Replace Spar# Plug(s) and adjust gap
Drain and replace oil for proper tempera rure
Push Clutch/Brake Pedal into brake poaition
Charge or replace Battery
Move Arteehment Clutch Lever to "DISENGA GED "position
Replace Ignition Switch
Replace Interlock Switchfes)
Replace Solenoid or Starter
Replace .Spark Plug(s}
Replace Fuse
Check all Wire Connections and "'Ground" Points
Clean Battery Termlna/s
Replace Starter or Solenoid
Charge or Replace Battery
Check Wire Connections and "Ground'" Points
Place Throttle Control in "FAST'position and run
starter leveret times to clear cut gas
Remove Air Filter and clean
Replace Spark Plug(s) and adjust gap
Recharge or replace Battery
Check the Wiring
Drain Fuel Tank and Carburetor, Use Fresh FueL,
Replace Fuel Filter
Make necessary adjustments to Carburetor
Major Engine Overhaul
Shift to a lower gear or reduce feed
Drain Gas Tank and Carburetor Use Fresh Fuel
Rome ve at_d clean Air Cleaner
Make necessary carburetor adjustments
Clean Air Screen
Add or change oil
Replace Spark Plug(s) and adjust gap
Replace Fuel Filter
Major Engine Overhaul
Shift to Iower gear or reduce load
Clean Air Screen
Add or change oil
Clean Engine Cooling Fins
Remove and clean Muffler or replace
Remove and clean Air Ftlter
U_e fresh fuel and adjust Carburetor
Cheek Fuut, Switch and Wire Connections. Replace
Headlight Bulbs
Replace Switch
Check Fu_e for fault and replace
Replace Battery
Replace Diode Aeeembfy
!Replace Alternator
I
l
SHUT DOWN ENGINE WHEN OPERATOR LEAVES EngageAttaehmentClutch
Check all Wire Connections
SEAT CheckSeatSwitch
NOTE:' This tractor ia equipped with at_ opet"ator pre_ence
tensing ry_te'n. Any attempt bY the oper#torto leave the _t
;with the engine running and the attachment clutch engaged
will shut down the engine.
27
