Filter
Top Products
Contents
About this manual. . . . . . . . . . . iii
Chapter 1. Safety information . . . . . . 1
General safety . . . . . . . . . . . . . . . . 1
Electrical safety . . . . . . . . . . . . . . . 2
Safety inspection guide . . . . . . . . . . . . 3
Handling devices that are sensitive to electrostatic
discharge. . . . . . . . . . . . . . . . . . 3
Grounding requirements . . . . . . . . . . . . 4
Safety notices (multilingual translations) . . . . . . 4
Laser compliance statement (multilingual
translations) . . . . . . . . . . . . . . . . 17
Chapter 2. Important service
information . . . . . . . . . . . . . . 25
Strategy for replacing FRUs . . . . . . . . . 25
Strategy for replacing a hard disk drive or solid
state drive. . . . . . . . . . . . . . . 26
Important notice for replacing a system
board . . . . . . . . . . . . . . . . 26
How to use error message . . . . . . . . 26
Strategy for replacing FRUs for CTO, CMV, and
GAV . . . . . . . . . . . . . . . . . . . 26
Product denition. . . . . . . . . . . . 26
FRU identication for CTO, CMV, and GAV
products . . . . . . . . . . . . . . . 27
Chapter 3. General checkout . . . . . 29
What to do rst . . . . . . . . . . . . . . 29
Checkout guide . . . . . . . . . . . . . . 30
System supporting the Lenovo ThinkVantage
Toolbox program and the PC-Doctor for DOS
diagnostics program . . . . . . . . . . 30
System supporting the Lenovo diagnostics
programs . . . . . . . . . . . . . . . 35
Power system checkout . . . . . . . . . . . 37
Checking the ac adapter . . . . . . . . . 37
Checking operational charging . . . . . . 38
Checking the battery pack . . . . . . . . 38
Checking the backup battery . . . . . . . 39
Chapter 4. Related service
information . . . . . . . . . . . . . . 41
Restoring the factory contents by using Recovery
Disc Set . . . . . . . . . . . . . . . . . 41
Passwords . . . . . . . . . . . . . . . . 42
Power-on password . . . . . . . . . . . 42
Hard-disk password. . . . . . . . . . . 42
Supervisor password . . . . . . . . . . 43
How to remove the power-on password . . . 43
How to remove the hard-disk password . . . 43
Power management . . . . . . . . . . . . 44
Screen blank mode . . . . . . . . . . . 44
Sleep (standby) mode . . . . . . . . . . 44
Hibernation mode . . . . . . . . . . . 45
Symptom-to-FRU index . . . . . . . . . . . 45
Numeric error codes . . . . . . . . . . 46
Error messages . . . . . . . . . . . . 50
Beep symptoms . . . . . . . . . . . . 51
No-beep symptoms . . . . . . . . . . . 52
LCD-related symptoms . . . . . . . . . 52
Intermittent problems . . . . . . . . . . 52
Undetermined problems . . . . . . . . . 53
Chapter 5. Installing and conguring
RAID . . . . . . . . . . . . . . . . . . 55
Supported RAID congurations . . . . . . . . 55
Conguring the system BIOS to enable embedded
SATA RAID functionality . . . . . . . . . . . 55
Creating RAID volumes . . . . . . . . . . . 55
Deleting RAID volumes . . . . . . . . . . . 56
Chapter 6. Status indicators . . . . . 57
Chapter 7. Fn key combinations . . . 61
Chapter 8. FRU replacement
notices . . . . . . . . . . . . . . . . 65
Screw notices . . . . . . . . . . . . . . . 65
Retaining serial numbers. . . . . . . . . . . 66
Restoring the serial number of the system
unit . . . . . . . . . . . . . . . . . 66
Retaining the UUID . . . . . . . . . . . 67
Reading or writing the ECA information . . . 67
Chapter 9. Removing and replacing a
FRU . . . . . . . . . . . . . . . . . . 69
Before servicing ThinkPad T510, T510i, and
W510 . . . . . . . . . . . . . . . . . . 70
1010 Battery pack . . . . . . . . . . . . . 70
1020 Serial Ultrabay Enhanced device or travel
bezel . . . . . . . . . . . . . . . . . . 71
1030 DIMM slot cover. . . . . . . . . . . . 73
1040 DIMM (bottom slot). . . . . . . . . . . 73
1050 Hard disk drive slot cover, hard disk drive and
HDD rubber rails or solid state drive and storage
converter . . . . . . . . . . . . . . . . . 74
1060 Keyboard . . . . . . . . . . . . . . 76
© Copyright Lenovo 2009, 2012
i
Downloaded from LpManual.com Manuals