Filter
Top Products
MATERIAL SAFETY DATA SHEET
Data Revised: Jun.28.2002
Data Issued: Nov.1.2000
MSDS NO. F-31001
100
8. EXPOSURE CONTROL / PERSONAL PROTECTION
Engineering Measures
Ventilation :None required with intended use.
Exposure limit values
OSHA-PEL (USA) :15mg/m
3
(Total Dust) , 5mg/m
3
(Respirable Dust)
ACGIH-TLV (USA) :10mg/m
3
(Total Dust) , 3mg/m
3
(Respirable Dust)
Personal Protective Equipment
Respiratory Protection :Not required under intended use.
Hand Protection :Not required under intended use.
Eye Protection :Not required under intended use.
Skin Protection :Not required under intended use.
Other Protective equipment :Use of a dust mask and goggles are recommended when
handling a large quantity of toner or during long term exposure,
as with any non-toxic dust.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State : Solid Form: Powder Color: Black Odor: odorless
Ph :Not applicable
Boiling/Melting Point :Not applicable
Softening Point (°C) :No data
Flash Point (°C ) :Not applicable
Ignition Point (°C ) :No data
Explosion Properties :No data
Density (g/cm
3
) :1.1 (bulk density : 0.34)
Solubility in water :Negligible
10. STABILITY AND REACTIVITY
Stability :Stable
Hazardous Reactions :Dust explosion, like most finely divided organic powders.
Conditions to avoid :Electric discharge, throwing into fire.
Materials to avoid :Oxidizing Materials
Hazardous Decomposition Products:CO, CO
2
and NO
X
Further Information :None
11. TOXICOLOGICAL INFORMATION
Acute Toxicity
Ingestion (oral) :LD
50
>2000mg/kg (Rats)
Dermal :LD
50
>2000mg/kg (Rats)
Inhalation :No data
Eye irritation :Not an irritant
Skin irritation :Not an irritant
Skin sensitizer :No sensitization
Mutagenicity :Negative (Ames Test)
Carcinogenicity
:In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible
human carcinogen). This classification is given to chemicals for which there is
inadequate human evidence, but sufficient animal evidence on which to base an
opinion of carcinogenicity. The classification is based upon the development of
lung tumors in rats receiving chronic inhalation exposures to free carbon black at
levels that induce particle overload of the lung. Studies performed in animal
models other than rats did not show any association between carbon black and
lung tumors. Moreover, a two-year cancer bioassay using a typical toner
preparation containing carbon black demonstrated no association between toner
exposure and tumor development in rats.
Page: 3/4