Toshiba 431A Power Supply User Manual


  Open as PDF
of 78
 
33
4300 Series Ancillary Cabinets Installation and Operation Manual
11.2 EQUIPMENT WARNING LABELS
DO NOT attempt to install, operate, maintain or dispose of this equipment until you have read and under-
stood all of the product warnings and user directions that are contained in this instruction manual.
FIgure 11-2 shows examples of warning labels that may be found attached to the equipment. DO NOT
remove or cover any of the labels. If the labels are damaged or if additional labels are required, contact
your TOSHIBA representative for additional labels.
The following are examples of the warning labels that may be found on the equipment. The labels are
there to provide useful information or to indicate an imminently hazardous situation that may result in seri-
ous injury, severe property and equipment damage, or death if the instructions are not followed.
(A) 40308 (B) 41750
(D) 49455
(C) 43784
(F) 66005
(E) 48082
Figure 11-2: Battery Cabinet Warning Labels
ENCASDUTILISATIONENATMOSPHERECONTROLEE.'
AVERTISSEMENT
CONSULTERLA NOTICETECHNIQUE.
WARNING-Riskofelectricshock
DONOT REMOVECOVER.NOUSERSERVICEABLEPARTS
INSIDE.REFERSERVICING TOQUALIFIEDSERVICEPERSONNEL.
HAZARDOUSLIVEPARTSINSIDE THISUPSAREENERGIZED
FROM THEBATTERY SUPPLY EVENWHEN THEINPUTACPOWER
ISDISCONNECTED.
CAPACITORSSTOREHAZARDOUSENERGY.DONOT REMOVE
COVERUNTIL 5MINUTESAFTERDISCONNECTING ALLSOURCES
OFSUPPLY.
BATTERY BACK-UP TIME,WHICHWASFACTORY-SETATA
PREDETERMINEDLEVEL,DECREASESGRADUALLY BETWEEN
SERVICEPERIODS. THEBATTERIESSHOULDBEREPLACED
EVERYTHREE YEARSAFTER THELAST SERVICING, THEDATE
OFWHICHISWRITTENON THEIDPLATELOCATEDON THE
REARSIDEOF THEUPSUNIT,ORINTHEBOXBELOW.
DATEOFLAST BATTERY CHARGE:
PN41750
4.00
4.00
PRINT -BLACK
MATERIAL -ULAPPROVED-3M7883
ADHESIVE-ULAPPROVED-3M300
TOREDUCE THERISKOFFIREORELECTRICSHOCK,INSTALL
INATEMPERATUREANDHUMIDITY CONTROLLEDINDOOR
AREAFREEOFCONDUCTIVECONTAMINANTS.
THISMATERIALIS THEEXCLUSIVEPROPERTY OF TOSHIBA INTERNATIONAL
CORPORATION ANDSHALL NOTBEREPRODUCED,USED,ORDISCLOSED
TO OTHERS UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
TITLE:
SCALE:
DRAWING NO.:
ECN DATE BY
DRAWN:
CHECKED:
APPROVED:
CAUTIONLABEL
10-18KVA UPS
41750
3=2
TF9-8-94
REV:
1
13131WEST LITTLE YORKROAD,HOUSTON, TX77041U.S.A.
ECO77296 07-09 ZIR
AMB07-09 AMB07-09
DANGER
DC VOLTAGE
DC Voltage supplied by batteries is still
present after equipment has been
turned off and taken off line.
Accidental contact with live parts can
cause personal injury and death.
Disconnect all DC Sources before
performing any service or testing
in this compartment.
MATERIAL - VINYL OR POLYESTER
TEMPERATURE - MINUS 20 TO 100 deg. C
ADHESIVE - V23 OR EQUIV.
MUST RESIST OIL SOLVENTS
ALL MATERIALS USED MUST
BE UL RECOGNIZED
WARNING AREA BACKGROUND COLOR: ANSI DANGER RED
WARNING AREA TEXT COLOR: ANSI WHITE
TEXT AREA BACKGROUND COLOR: ANSI WHITE
TEXT AREA TEXT COLOR: ANSI BLACK
CORNER RADIUS: VENDOR STANDARD
0.00
WARNING AREA
TEXT AREA
0.00
3.00
1.50
43784
THIS MATERIAL IS THE EXCLUSIVE PROPERTY OF TOSHIBA INTERNATIONAL
CORPORATION AND SHALL NOT BE REPRODUCED, USED, OR DISCLOSED
TO OTHERS UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
TITLE:
SCALE:
DRAWING NO.:
ECN DATE BY
DRAWN:
CHECKED:
APPROVED:
DANGER LABEL
DC VOLTAGE
43784
FULL
RCM 4-11-96
REV:
0
13131 WEST LITTLE YORK ROAD, HOUSTON, TX 77041 U.S.A.
TF 6-1-07 TF 6-1-07
UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
THIS MATERIAL IS THE EXCLUSIVE PROPERTY OF
BE REPRODUCED, USED OR DISCLOSED TO OTHERS
TOSHIBA INTERNATIONAL CORPORATION AND SHALL NOT
APPROVED BY DATE
CHECKED BY
DRAWN BY: DATE
DATE
DRAWING NO.
13131 WEST LITTLE YORK ROAD, HOUSTON, TX, 77041 U.S.A.
TITLE: SCALE
OFSH.
ORDER NO.
TOSHIBA INTERNATIONAL CORPORATION
TOSHIBA INTERNATIONAL CORPORATION
ECN# 63201
12-99
BC
1"=1"
1 1
49455
DISK: PRT
REV: 2
BC
12-8-99
E3 2.4-8kVA UPS WARNING LABEL SHEET
MATERIAL - POLYESTER
TEMPERATURE - MINUS 20 TO 100 deg. C
ADHESIVE - V23 OR EQUIV.
MUST RESIST OIL SOLVENTS
ALL MATERIALS USED MUST
BE UL RECOGNIZED
WARNING AREA BACKGROUND COLOR: ANSI WARNING ORANGE
WARNING AREA TEXT COLOR: ANSI BLACK
TEXT AREA BACKGROUND COLOR: ANSI WHITE
TEXT AREA TEXT COLOR: ANSI BLACK
----- INDICATES KISS CUT
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could re
sult
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
WARNING
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exp
loding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of prev
entative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
This unit contains sealed lead acid batteries.
Lack of preventative maintenance could result
in batteries exploding and emitting
gasses and/or
flame. Annual preventative maintenance must be
performed by an authorized, trained technician.
WARNING
WARNING
WARNING
WARNING
WARNING
WARNING
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
8.12"
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
WARNING
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequate
equipment protection.
Replace only with same type
and rating of fuse.
WARNING
CRITICAL FUSE SIZING
Incorrect fuse replacement size
may result in fire or inadequa
te
equipment protection.
Replace only with same type
and rating of fuse.
WARNING
10.40"
ECO 73600
04-07
AMB
MUST BE RoHS COMPLIANT
TF 5-3-07
TF 5-3-07
WARNINGAREA
TEXTAREA
DANGER
Hazardous voltages are used inthe operation
of this equipment and could cause severepersonal
injury or loss of life.
The following precautions should be observed to
reduce the risk of injury or death.
HAZARDOUS VOLTAGES
Only qualified technicians familiar with this equipmentand the
information supplied with it should be permittedto install and
operate this equipment.
Installation of electrical equipment mustbe done in
accordance with National Electrical Code and anyother state
or local codes. Proper grounding and conductor sizing must
be installed for safe operation.
During operation, keep all covers in placeand cabinet
doors shut.
When performing visual inspections and maintenance, if
possible, be sure the MBS is turnedoff and the incoming
AC feed is turned off and locked out.
If it is necessary to make measurements with the power
on, do not touch any electrical connectionpoints. Remove
all jewelry from wrists andfingers. Make sure test equipment
is in good, safe operating condition.
While servicing, stand on sometype of insulation, and be
sure not to be grounded.
Follow the safety instructions given in theequipment manual
carefully and observe all danger, warning and caution notices.
64818
MATERIAL - VINYL OR POLYESTER
TEMPERATURE - MINUS 20 TO 100 deg. C
ADHESIVE - V23 OR EQUIV.
MUST RESIST OIL SOLVENTS
ALL MATERIALS USED MUST
BE UL RECOGNIZED
WARNING AREA BACKGROUND COLOR: ANSI DANGER RED
WARNING AREA TEXT COLOR: ANSI WHITE
TEXT AREA BACKGROUND COLOR: ANSI WHITE
TEXT AREATEXT COLOR: ANSI BLACK
CORNER RADIUS: VENDOR STANDARD
0.00
0.00
3.75
4.50
The UPS and Battery Cabinet will havehazardous
voltages present evenafter theAC feed is turned off.
THISMATERIALISTHEEXCLUSIVEPROPERTYOFTOSHIBAINTERNATIONAL
CORPORATIONANDSHALL NOTBE REPRODUCED,USED,OR DISCLOSED
TO OTHERS UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
TITLE:
SCALE:
DRAWING NO.:
ECN DATE BY
DRAWN:
CHECKED:
APPROVED:
DANGER LABEL
GENERAL - MBS
64818
FULL
WLM 3-9-11
REV:
0
13131WESTLITTLEYORKROAD,HOUSTON,TX 77041U.S.A.
WLM 3-10-11
ZIR 3-10-11
40308
DANGER
AC VOLTAGE
This UPS receives power from more
than one source. Disconnect all AC
sources before performing any service
or testing inside this unit
MATERIAL - VINYL OR POLYESTER
TEMPERATURE - MINUS 20 TO 100 deg. C
ADHESIVE - V23 OR EQUIV.
MUST RESIST OIL SOLVENTS
ALL MATERIALS USED MUST
BE UL RECOGNIZED
WARNING AREA BACKGROUND COLOR: ANSI DANGER RED
WARNING AREA TEXT COLOR: ANSI WHITE
TEXT AREA BACKGROUND COLOR: ANSI WHITE
TEXT AREA TEXT COLOR: ANSI BLACK
CORNER RADIUS: VENDOR STANDARD
0.00
WARNING AREA
TEXT AREA
0.00
3.00
1.50
48082
THIS MATERIAL IS THE EXCLUSIVE PROPERTY OF TOSHIBA INTERNATIONAL
CORPORATION AND SHALL NOT BE REPRODUCED, USED, OR DISCLOSED
TO OTHERS UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
TITLE:
SCALE:
DRAWING NO.:
ECN DATE BY
DRAWN:
CHECKED:
APPROVED:
DANGER LABEL
MULTIPLE SOURCES
48082
FULL
BC 6-10-98
REV:
0
13131 WEST LITTLE YORK ROAD, HOUSTON, TX 77041 U.S.A.
TF 8-2-06 TF 8-2-06
32° AMBIENT
TEMPERATURE
0.50"
1.00"
THISMATERIALISTHEEXCLUSIVEPROPERTYOFTOSHIBAINTERNATIONAL
CORPORATIONANDSHALLNOTBEREPRODUCED,USED,ORDISCLOSED
TO OTHERS UNLESS PRIOR WRITTEN AUTHORIZATION IS OBTAINED.
TITLE:
SCALE:
DRAWING NO.:
ECN DATE BY
DRAWN:
CHECKED:
APPROVED:
LABELAMBIENT
32 C 4310 BC°
66005
2=1
WLM8-08-11
REV:
0
13131WESTLITTLEYORKROAD,HOUSTON,TX 77041U.S.A.
PRINT: BLACK
UL RECOGNIZED MATERIAL: 2-3 MIL MATTE METALLIC POLYESTER
UL RECOGNIZEDADHESIVE: 3M 300 SERIES OR EQUIV..
ZIR 8-08-11WLM 8-08-11
 previous next