Filter
Top Products
138
SHARP
Date Revised :
Date Issued : July. 16. 1999
MATERIAL SAFETY DATA SHEET (1/2)
MSDS No. P-00102
Section 1. Product Identification
Product: FO-2970/FO29ND,FO-29DC,FO-29DCCN (Black Toner)
Section 2. Supplier’s Name and Address
Sharp Corporation
22-22 Nagaike-cho, Abeno-ku, Osaka, Japan
Local suppliers are listed below. Please contact the nearest supplier for additional information.
Section 3. Ingredients
Ingredients CAS No. Proportion OSHA PEL ACGIH TLV Other Limits
Carbon black 1333-86-4 > 5% 3.5m /m
3
3.5m /m
3
None
Styrene-Acrylate copolymer 25036-16-2 > 90% Not listed Not listed None
Iron oxide 1317-61-9 < 2% Not listed Not listed None
Silica 68909-20-6 < 2% 0.8m /m
3
10m /m
3
None
Section 4. Hazardous Identification (Emergency Overview)
Toner is a fine, black powder possessing no immediate hazard. There are no anticipated carcinogenic
effects from exposure based on animal tests performed using toner. When used as intended according to
instructions, studies do not indicate any symptoms of fibrosis will occur.
Section 5. Health Hazard Data
Route(s) of Entry : Inhalation? Skin? Ingestion?
Yes No Possible but very unusual.
Health Hazards : Acute oral toxicity—LD50 of this toner is over 2,000m /k .
Mutagenicity—The result of Ames test is negative.
Carcinogenicity : In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possi-
ble human carcinogen). This classification is given to chemicals for which there is inadequate
human evidence, but sufficient animal evidence on which to base an opinion of carcinogenic-
ity. The classification is based upon the development of lung tumors in rats receiving chronic
inhalation exposures to free carbon black at levels that induce particle overload of the lung.
Studies performed in animal models other than rats did not show any association between
carbon black and lung tumors. Moreover, a two-year cancer bioassay using a typical toner
preparation containing carbon black demonstrated no association between toner exposure
and tumor development in rats.
Chronic Effect : In a study in rats of chronic inhalation exposure to a typical toner, a mild to
moderate degree of lung fibrosis was observed in 92% of the rats in the high concentration
(16m /m
3
) exposure group, and a minimal to mild degree of fibrosis was noted in 22% of the
animals in the middle (4m /m
3
) exposure group, but no pulmonary change was reported in
the lowest (1m /m
3
) exposure group, the most relevant level to potential human exposures.
Signs and Symptoms of Exposure : Minimal irritation to respiratory tract may occur as with exposure
to any non-toxic dust.
Medical Conditions Generally Aggravated by Exposure : None
(Country)
U.S.A
Canada
United
Kingdom
(Name and Telephone Number)
Sharp Document Network System of America
Telephone number for information : 1-800-237-4277
Emergency telephone number : 1-800-255-3924
Sharp Electronics of Canada Ltd.
Telephone number for information : 905-890-2100
Emergency telephone number : 1-800-255-3924
Sharp Electronics (U.K.) Ltd.
Telephone number for information : 01923-474013
all-fo2970.book Page 138 Monday, July 24, 2000 7:45 AM